caryle

2016 Nissan Titan XD maintenance schedule

The 2016 Titan XD is part of the H61 generation (2016-2024), sold as a pickup. Below: its service intervals with the source behind each one, the fluids it takes, the problems owners report for this year, and the NHTSA recalls issued for it.

Service schedule

What the 2016 Titan XD needs, and when

Manufacturer rows link to Nissan's own schedule, Independent rows to a service shop or parts retailer's published guide.

ServiceIntervalSource
Engine oil and filter (5.0L Cummins)

Drops to 5,000 miles / 6 months under severe operating conditions

10,000 mi / 1 yearIndependent
Engine air filter (5.0L Cummins)30,000 mi / 3 yearsIndependent
Cabin air filter15,000 mi / 1 yearIndependent
Brake fluid

Drops to 10,000 miles / 12 months under severe duty

20,000 mi / 2 yearsIndependent
Engine coolant (5.0L Cummins)45,000 mi / 3 yearsIndependent
Engine coolant (5.6L V8)105,000 mi / 86 monthsIndependent
Transmission fluid (5.0L Cummins)

Includes transmission filter replacement

20,000 mi / 2 yearsIndependent
Spark plugs (5.6L V8)105,000 mi / 86 monthsIndependent
Serpentine belt (5.0L Cummins)

Inspect at 10,000 miles / 12 months

Inspect, replace as neededIndependent
Differential and transfer case fluid

Required for 4WD and towing applications

20,000 mi / 2 yearsIndependent
Fuel filter (5.0L Cummins)

Absolute strict requirement to protect CP4 pump; drain water separator at 5,000 miles

10,000 mi / 1 yearIndependent

Intervals are for normal driving; towing, short trips, extreme heat or dust shorten them. Services we could not find an interval for are left off rather than guessed.

Fluids and engines

What goes in it

Engine oil
10W-30 or 5W-40 (Diesel) / 0W-20 (Gas)
Coolant
Nissan Long Life Antifreeze (Blue)
Transmission fluid
Nissan Matic-K (Diesel) or Matic-P (Gas)

Powertrains in this generation

  • 5.0 L 8-cyl diesel (ISV5.0), 6-speed automatic, RWD or 4WD
  • 5.6 L 8-cyl (VK56), 7-speed automatic, RWD or 4WD

Confirm the exact spec against the owner's manual or the label under the hood; capacities vary by engine and drivetrain.

Known problems

What 2016 Titan XD owners run into

Problems reported for this model year, with the mileage they tend to show up at. Buying past a window is not automatically a pass - it just needs to be priced in.

CP4 fuel pump catastrophic failure

high severity

40,000-150,000 mi · $10,000 to fix

Metallic glitter in fuel lines, sudden stall

Source: bostechauto.com

DEF / DPF faults

high severity

Limp mode, NOx sensor malfunction, engine fault dashboard warning

Source: repairpal.com

EGR valve carbon binding

medium severity

60,000-80,000 mi · $400-$1,200 to fix

P0401/P0404 codes, flow insufficient

Source: supmodlab.com

Safety recalls

3 NHTSA recalls for the 2016 Nissan Titan XD

From NHTSA's recall database, matched by model and year. Recall repairs are free at Nissan dealers, and a given car may already be fixed or fall outside a campaign, so check the VIN at nhtsa.gov/recalls before you buy.

Equipment

NHTSA 18V240000

April 2018

Nissan North America, Inc. (Nissan) is recalling certain 2016-2018 Nissan Titan, 2016 and 2018 Nissan Titan XD vehicles. Accessories installed on these vehicles reduced the load carrying capacity, however, a Load Carrying Capacity modification label was not installed, possibly allowing the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Remedy: Nissan will notify owners and provide a new modification label, with installation instructions, free of charge. The recall began on June 4, 2018. Owners may contact Nissan customer service at 1-800-867-7669.

Seat belts

NHTSA 17V268000

April 2017

Nissan North America, Inc. (Nissan) is recalling certain 2016-2017 Nissan Titan Crew Cab and Titan XD Crew Cab vehicles. In the event of a crash, the rear seatbelt assembly may not adequately protect the occupant's head, allowing it to contact the D-ring bolt trim cap. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 201, "Occupant Protection in Interior Impact."

Remedy: Nissan will notify owners, and dealers will install energy absorbing material to the C-Pillar Finishers and replace the Seatbelt Bolt and Bolt Cap, free of charge. The recall began September 19, 2017. Owners may contact Nissan customer service at 1-800-647-7261.

Fuel system, diesel

NHTSA 16V847000

November 2016

Nissan North America, Inc. (Nissan) is recalling certain model year 2016 Titan Diesel XD vehicles manufactured August 7, 2015, to September 1, 2016. The affected vehicles may not have had the temporary fuel tank breather tube cap removed during the vehicle's assembly and the fuel tank breather tube may not have been connected to the bed rail. As a result, the fuel tank may not have the proper ventilation, possibly causing the fuel gauge and the distance to empty meter to both display inaccurately.

Remedy: Nissan will notify owners, and dealers will inspect the fuel tank breather tube, replacing the fuel tank, fuel sending unit, and/or fuel tank breather tube, as necessary, free of charge. The recall began on December 12, 2016. Owners may contact Nissan customer service at 1-800-647-7261.

Running costs

What maintenance typically costs

A typical year of maintenance
$511

Typical US independent-shop estimates for this generation; they vary by region and condition.

Other Titan XD model years

H61 (2016-2024)

201620172018201920202021202220232024

Shopping new? The Nissan Titan XD guide covers the current model, with what it costs to keep for 1 to 15 years.

Sources

Researched 2026-09-21. Modeling, not mechanic advice - always confirm against your car's owner's manual and service records.

Running a Titan XD for income?

Carlyle scores the exact listing on cost per remaining mile and projected Turo income, so you know what a 2016 Titan XD earns before you buy it.

Start your fleetBuying one for yourself

Free to start. No card, and we never sell your details to a dealer.